National Nut Grower National Nut Grower

Sep 22, 2022
After the rain: Maintaining almond nut quality

Many Sacramento Valley almond growing received almost 2” of rain recently. While any rain is needed, this storm left wet almonds behind. If those nuts are not allowed to dry to delivery standards for moisture, mold can grow. Nut quality and grower returns will suffer. Careful treatment of rain-wet nuts will maintain quality and deliver the best returns possible to growers in a buyers’ market.

Nut pick up:

Let hulls dry completely on the orchard floor before pick up. Good drying weather is in the forecast. Patience is needed, but good drying weather is on the way and the nuts should dry to a high-quality product if allowed to. Here are some critical points to delivering quality to the huller:

  • Roll nuts lying flat (not windrowed) to maximize exposure to air and sun. Blow loose nuts from under the trees out into the drive rows where there is more sun light.
  • Condition windrowed nuts wet by the rain. This is critical to faster drying.
  • Do not pick up wet nuts. Target moisture levels for pick up = hull moisture below 12%, kernel moisture below 6%, or total fruit (hull and kernel) moisture under 9%. For reference, hulls snap at or below 11-12% moisture. Wet nuts going directly to the huller will not hull cleanly (embedded shell, etc.) and quality will suffer. Stockpiling wet nuts risks mold and concealed damage.
  • Get a good sample when making decisions about moving nuts rained on this past week. Moisture levels can vary by 2% from the top to the bottom of the windrow or from near the tree trunk (shaded) to the row middles. Sample equally from all areas.

It is the start of fall and good drying weather is forecast. There should be no need to take nuts to open space for air drying or a commercial gas-fired dryer to deliver a quality crop, but those are options if the nuts need to be moved out of the orchard.

Avoid moisture accumulation with covered stockpiles designed in north-south orientations, with flat/smooth tops, and ideally on a raised surface to avoid ponding. Photo: Almond Board of California

Stockpile management:

If covered to fumigate for navel orangeworm control or because of a forecast rain, take steps at setup to avoid moisture accumulation inside the stockpile. Ideally, stockpile sites should be on higher, well-drained areas to avoid puddling around the edges. Orient stockpiles north-south to get the most sun exposure possible to as many surfaces as possible. Piles should have smooth and flat tops, avoiding low spots where condensation allows water to accumulate.

University of California research recommends white on black tarps help avoid severe temperature fluctuations that increase condensation. Mel Machado (Blue Diamond) disagrees, he prefers clear plastic so that condensation on the inside of the plastic can be noticed promptly and the pile vented.

Remove tarps when fumigation is finished and/or dry weather in the forecast. North winds are a great, free nut dryer. For more information on stockpile practices from Almond Board of California and University of California, click HERE.

– Franz Niederholzer, advisor, University of California Cooperative Extension; Luke Milliron, orchards advisor, University of California Cooperative Extension; Bruce Lampinen, tree nut Extension specialist, University of California, Davis

 



Be sure to check out our other specialty agriculture brands

produceprocessingsm Organic Grower

75 Applewood Drive, Suite A
P.O. Box 128
Sparta, MI 49345
frontdesk@greatamericanpublish.com
616.520.2137
Get one year of National Nut Grower in both print and digital editions.

Interested in reading the print edition of National Nut Grower?

Subscribe Today »